Hyatt Regency walkway collapse

The Hyatt Regency walkway collapse took place at the Hyatt Regency Kansas City hotel in Kansas City, Missouri, on July 17, 1981. Two vertically contiguous walkways collapsed onto a tea dance being held in the hotel's lobby. The falling walkways killed 114 and injured 216.^[2] At the time, it was the deadliest structural collapse in U.S. history,^[3] not surpassed until the collapse of the south tower of the World Trade Center in 2001.

Background

The construction of the 40-story Hyatt Regency Kansas City began in May 1978. Despite delays and setbacks, including an incident on October 14, 1979 when 2,700 square feet (250 m²) of the atrium roof collapsed due to the failure of one of the connections at its northern end, the hotel officially opened on July 1, 1980.

One of the defining features of the hotel was its lobby, which incorporated a multistory atrium spanned by elevated walkways suspended from the ceiling. These steel, glass and concrete crossings connected the second, third and fourth floors between the north and south wings. The walkways were approximately 120 ft (37 m) long^[4] and weighed approximately 64,000 lb (29,000 kg).^[5] The fourth level walkway aligned directly above the second level walkway.

Disaster

Aftermath of the walkway collapse

On the evening of July 17, 1981, approximately 1,600 people gathered in the atrium to participate in and watch a tea dance.^[6] At 7:05 p.m. the second-level walkway held approximately 40 people with more on the third and an additional 16 to 20 on the fourth level who watched the activities of the crowd in the lobby below.^[4] The fourth-floor bridge was suspended directly over the second-floor bridge, with the third-floor walkway offset several meters from the others. Construction difficulties resulted in a subtle but flawed design change that doubled the load on the connection between the fourth-floor walkway support beams and the tie rods carrying the weight of both walkways. This new design was barely adequate to support the dead load weight of the structure itself, much less the added weight of the spectators. The connection failed, and the fourth-floor walkway collapsed onto the second-floor walkway. Both walkways then fell to the lobby floor below, resulting in 111 deaths at the scene and 219 injuries. Three additional victims died after being transported to hospitals, bringing the total number of deaths to 114.^[7]

The rescue operation lasted 14 hours^[8] and was performed by many emergency personnel, including crews from 34 fire trucks and EMS units and doctors from five local hospitals. Trapped survivors were buried beneath more than 60 tons of steel, concrete and glass, which neither the Hyatt's forklifts nor the fire department's most powerful jacks could move. Additional volunteers from surrounding areas responded to the fire department's requests for help, including construction companies and building-supply stores, bringing hydraulic jacks, acetylene torches, compressors and generators.^[9] Kansas City's natural disaster response team, known as "Operation Bulldozer", was also summoned to the scene with earthmoving equipment, but was quickly sent away to make room for cranes that would lift the sections of walkway off the trapped survivors. Dr. Joseph Waeckerle, former chief of Kansas City's emergency medical system, directed the rescue effort ^[2] establishing a makeshift morgue in a ground floor exhibition area,^[10] using the hotel's driveway and front lawn as a triage area and helping to organize the wounded by greatest need for medical care.^[11] Those people who could walk were instructed to leave the hotel to simplify the rescue effort; those mortally injured were told they were going to die and given morphine.^[7][12] Often, rescuers had to dismember bodies in order to reach survivors among the wreckage.^[7] One victim's right leg was trapped under an I-beam and had to be amputated by a surgeon, a task which was completed with a chainsaw.^[13]

One of the great challenges of the rescue operation was that the hotel's sprinkler system had been severed by falling debris, flooding the lobby and putting trapped survivors at great risk of drowning. As the pipes were connected to water tanks, not a public source, the flow could not be stopped. Mark Williams, the last person rescued alive from the rubble, spent more than nine and a half hours pinned underneath the lower skywalk with both of his legs pulled out of their sockets.^[14] Williams nearly drowned before Kansas City's fire chief realized that the hotel's front doors were trapping the water in the lobby. On his orders, a bulldozer was sent to break through the doors, which allowed the water to pour out of the lobby and thus eliminated the danger to those trapped. A fire hose was then placed over the broken pipe, redirecting the water outside the hotel. Additionally, the lobby was filled with concrete dust, and visibility was poor as the emergency workers had cut the power to prevent fires.^[15]

Twenty-nine people were rescued from the rubble.^[16]

Investigation

Investigators found that changes to the design of the walkway's steel tie rods were the cause of its failure.

Three days after the disaster, Wayne G. Lischka,^[17] an architectural engineer hired by The Kansas City Star newspaper, discovered a significant change of the original design of the walkways. Reportage of the event later earned the Star and its associated publication the Kansas City Times a Pulitzer Prize for local news reporting in 1982.^[18] Radio station KJLA would later earn a National Associated Press award for its reporting on the night of the disaster.

The two walkways were suspended from a set of 1.25 in (32 mm) diameter^[19] steel tie rods, with the second floor walkway hanging directly under the fourth floor walkway. The fourth floor walkway platform was supported on three cross-beams suspended by steel rods retained by nuts. The cross-beams were box girders made from C-channel strips welded together lengthwise, with a hollow space between them. The original design by Jack D. Gillum and Associates specified three pairs of rods running from the second floor to the ceiling. Investigators determined eventually that this design supported only 60 percent of the minimum load required by Kansas City building codes.^[20]

Havens Steel Company, the contractor responsible for manufacturing the rods, objected to the original plan, since it required the whole of the rod below the fourth floor to be screw threaded in order to screw on the nuts to hold the fourth floor walkway in place. These threads would probably have been damaged and rendered unusable as the structure for the fourth floor was hoisted into position with the rods in place. Havens therefore proposed an alternate plan in which two separate sets of tie rods would be used: one connecting the fourth floor walkway to the ceiling, and the other connecting the second floor walkway to the fourth floor walkway.^[21]

This design change proved fatal. In the original design, the beams of the fourth floor walkway had to support only the weight of the fourth floor walkway, with the weight of the second floor walkway supported completely by the rods. In the revised design, however, the fourth floor beams were required to support both the fourth floor walkway and the second floor walkway hanging from it. With the load on the fourth-floor beams doubled, Havens' proposed design could bear only 30 percent of the mandated minimum load (as opposed to 60 percent for the original design).

The serious flaws of the revised design were compounded by the fact that both designs placed the bolts directly through a welded joint connecting two C-channels, the weakest structural point in the box beams. Photographs of the wreckage show excessive deformations of the cross-section.^[22] During the failure, the box beams split along the weld and the nut supporting them slipped through the resulting gap between the two C-channels which had been welded together.

Investigators concluded that the basic problem was a lack of proper communication between Jack D. Gillum and Associates and Havens Steel. In particular, the drawings prepared by Jack D. Gillum and Associates were only preliminary sketches but were interpreted by Havens as finalized drawings. Jack D. Gillum and Associates failed to review the initial design thoroughly, and accepted Havens' proposed plan without performing basic calculations that would have revealed its serious intrinsic flaws — in particular, the doubling of the load on the fourth-floor beams.^[20] It was later revealed that when Havens called Jack D. Gillum and Associates to propose the new design, the engineer they spoke with simply approved the changes over the phone, without viewing any sketches or performing calculations.

Aftermath

The engineers employed by Jack D. Gillum and Associates who had approved the final drawings were found culpable of gross negligence, misconduct and unprofessional conduct in the practice of engineering by the Missouri Board of Architects, Professional Engineers, and Land Surveyor. All lost their respective engineering licenses in the states of Missouri, Kansas and Texas and their membership with ASCE.^[22] Although the company of Jack D. Gillum and Associates was discharged of criminal negligence, it lost its license to be an engineering firm.^[20]

At least $140 million was awarded to victims and their families in both judgments and settlements in subsequent civil lawsuits; a large amount of this money was from Crown Center Corporation, a wholly owned subsidiary of Hallmark Cards which was the owner of the hotel real estate (like many hoteliers, Hyatt operates hotels for a fee as a management company, and does not usually own the real estate). Life and health insurance companies likely absorbed even larger uncompensated losses in policy payouts.

The Hyatt collapse remains a classic model for the study of engineering ethics and errors, as well as disaster management.^[23] As an engineer of record for the Hyatt project, Jack D. Gillum (1924–2012)^[24] occasionally shared his experiences at engineering conferences in the hope of preventing future mistakes.^[25]

After the disaster, the lobby was reconstructed with only one crossing on the second floor. Unlike the previous walkways, the new bridge is supported by several columns underneath it rather than being suspended from the ceiling. As a result, the third floor of the hotel now has disconnected sections on opposite sides of the atrium, so it is necessary to go to the second floor to get to the other side.

Several rescuers suffered considerable stress due to their experience, and later relied upon each other in an informal support group.^[8] Jackhammer operator "Country" Bill Allman committed suicide.^[26]

The hotel was renamed the Hyatt Regency Crown Center in 1987, and again the Sheraton Kansas City at Crown Center in 2011. It has been renovated numerous times since, though the lobby retains the same layout and design. The hotel's owner announced a $13-million renovation as part of its re-flagging to the Sheraton brand completed in 2012.

Memorial

In 2008, the Skywalk Memorial Foundation announced a fundraising campaign to build a garden and a fountain in Washington Square Park, about a block from the hotel, commemorating the event. Hallmark Cards had pledged $25,000 and the city has offered $200,000. A Korean War memorial is now planned for the park and in May 2009 city officials said they were considering locating the memorial in Hospital Hill Park at 22nd Street and Gillham Road. On July 17, 2011 (the 30th anniversary of the collapse),the Skywalk Memorial Foundation unveiled the design for a memorial that is to be erected in Hospital Hill Park on 22nd and Gillham, across the street from the Sheraton. Hyatt and by Hallmark Cards had given official permission to erect the memorial. In 2011, Hyatt Hotels informed the Skywalk Memorial Foundation that it would not contribute to a memorial fund because the hotel is no longer managed by Hyatt and has become a Sheraton hotel. Sheraton and its parent company, Starwood Hotels and Resorts, donated $5,000 toward the cost of the memorial, saying in a statement, "Sheraton and Starwood are very aware and respectful of Kansas City's deep ties to this hotel and want to be a part of the effort to honor the victims, survivors, first responders and family members of the 1981 tragedy." The Skywalk Memorial Foundation (SMF) consisted of a board of directors and numerous others who have volunteered their time and resources to this cause. The SMF announced plans to break ground for the new memorial, following a ten-year fundraising effort. On June 15, 2015, the Overland Park City Council voted to approve a $25,000 grant to help build the memorial. Donations have come into the Greater Kansas City Community Foundation (GKCCF), the steward of the funds, from businesses, law firms, small companies and private individuals. On July 17, 2015, exactly 34 years to the day of the tragedy, the memorial started construction at 22nd and Gillham. It was completed and presented in a dedication ceremony on Thursday, November 12, 2015.^[27]

Notable victims

Linda Louise Rokey Scurlock, mother of former Flaming Lips drummer Kliph Scurlock and member of the Mariachi Estrella de Topeka, died during the collapse.^[28] Scurlock, Dolores Galvan, Connie Alcala, and Dolores Carmona died; only Teresa Cuevas and Rachel Galvan Sangalang survived. The band was about to perform and were walking across a skywalk when the collapse occurred.^[29]

See also

• Engineering disasters
• Kemper Arena
• List of structural failures and collapses
• Structural failure

References

Further reading

• Petroski, Henry. To Engineer Is Human: The Role of Failure in Structural Design. ISBN 978-0-679-73416-1. 
• Marshall, Richard D.; et al. (May 1982). Investigation of the Kansas City Hyatt Regency walkways collapse. Building Science Series. 143. U.S. Dept. of Commerce, National Bureau of Standards. Retrieved 2012-03-13. 
• Levey, M.; Salvadori, M.; Woest, K. (1994). Why Buildings Fall Down: How Structures Fail. W. W. Norton & Company. ISBN 978-0-393-31152-5. 
• Murphy, Kevin; Rick Alm and Carol Powers. The Last Dance : The Skywalks Disaster and a City Changed : In Memory, 30 Years Later. Kansas City Star Books (1st ed.). Kansas City, Mo. ISBN 978-1-61169-012-5.  – (All author royalties of this book are being donated to the memorial project)

External links

Wikimedia Commons has media related to Hyatt Regency walkway collapse.

• Engineering Ethics – includes photos of the failed walkway components
• Failure By Design – physics presentation and resources
• Network news feature from July 23, 1981, including interviews

Coordinates: 39°05′06″N 94°34′48″W / 39.085°N 94.580°W / 39.085; -94.580