AirStrato

AirStrato
Role Unmanned aerial vehicle
Manufacturer ARCA
First flight February 28, 2014
Status flight testing
Produced 3
Unit cost
between $80,000 and $140,000

AirStrato is a solar powered medium-sized unmanned aerial vehicle currently in development at ARCA. There are currently two variants available, AirStrato Explorer with a flight ceiling of 18,000 m and AirStrato Pioneer with a flight ceiling of 8000 m. It can cary a 45 kg payload consisting of surveillance equipment, scientific instruments or additional battery pods for extended autonomy.[1][2] The first prototype maiden flight took place on February 28, 2014. It was equipped with a fixed landing gear. Two more prototypes were constructed that lacked a landing gear. Instead ARCA opted for a pneumatic catapult as a launcher and landing skids and a recovery parachute for landing. Both prototypes performed take-off and landing testing and low altitude flights.

Development

AirStrato prototype 001 before takeoff

AirStrato was first presented by ARCA on February 10, 2014 as an alternative to the stratospheric balloons that had been used before in missions involving the Helen and Stabilo programs and the high altitude flights for the ExoMars program. Although capable of carrying less payload than a helium or solar balloon, the aircraft had a much lower cost per mission and could stay in the stratosphere for longer periods of time. Unlike a weather balloon that could not be steered and relied on wind forecasts to predict its trajectory the AirStrato could be remote controlled by a pilot on the ground. At that time ARCA designed the UAV to fulfill its own requirements for high altitude equipment testing and had a commercial version of the aircraft for consideration. The first prototype was equipped with a fixed landing gear and had two electric motors.

After a series of runway testing on rough ground, suspensions were added to the landing gear to improve handling and the number of electric motors was increased to four. The first prototype flew on February 28, 2014. ARCA released several images of AirStrato taking off and flying at very low altitude. The press release stated that the right landing gear suspension was damaged on landing.[3]

For nine months ARCA did not make public any news on the progress of the program, until November 10 when it released a short teaser on the aircraft featuring two other models in red and yellow colours performing flights. The two models lacked a landing gear. On its website it presented the aircraft as intended to fill a gap between large military grade UAV and small scale affordable drones for small businesses and individuals. On November 25 it made public the product website alongside a much longer video presenting the aircraft taking off from a pneumatic launcher and performing low altitudes flights. The aircraft were equipped with landing skids and deployable parachutes. Two versions of the aircraft are available, a larger stratospheric flying model with longer endurance, named Explorer and a slightly smaller version indended for lower altitudes and having less endurance, namde Pioneer.[4]

Design

Airframe

The airframe is constructed entirely from composite materials making possible for radio antennae to be placed inside the fuselage instead of outside such is usual for normal aircraft. At the base of the fuselage, underneath the wings there are two skids used for mounting and sliding across the side rails of the pneumatic catapult. Another small skid is installed underneath the frontal part of the fuselage that attaches to the middle rail of the catapult. Two more large skids are placed at the far edge of the wings. The parachute container is installed in the frontal part of the fuselage. The parachute can be deployed for landing or in case of emergency.[5]

Engines and power

Six electric driven propeller engines are installed on the wings that generate a combined thrust of 250 lbf at sea level. Although the power output remains constant as altitude increases the propellers lose their effectiveness but are still able to provide cruising speed of 152 km/h at altitude for the Explorer and 100 km/h for the Pioneer. The electrical motors are powered by internal batteries during night and solar panels during daytime. The solar panels generate 2800W for the Explorer and 1800W for the Pioneer.[6]

Avionics and control

The aircraft are equipped with inertial flight stabilization and autopilot. The GPS is linked with the transponder providing both altitude and coordinates, capable of being integrated into the US NextGeneration Air Transportation System. The control is via internet, using GSM networks where available and satellite connection everywhere else. The autopilot prevents the aircraft from entering restricted areas, can automatically takeover flying in case all communication is lost and attempt to contact ARCA technical support in case of emergency. It also is able to fly to a predetermined secure area and automatically deploy the parachute in case connection can no longer be established. The autopilot can also control the on-board camera to target specific locations and film them for a pre-determined period of time. The connection between the aircraft and the ground pilot are ecrypted using Transport Layer Security with AES 256 encryption standard.[7]

Pneumatic launcher

A compressed air catapult is used as a takeoff method for both models. The internal pneumatic piston has a force of 2,200 lbf, able to propel the aircraft to take-off speed in less than a second. It is also constructed from composite materials and has an internal compressor that requires an external power source (power outlet or generator). It is made of three parts: the upper part that contains the rails, compressor and canister and the leg that is made of the main part and a crosspiece.[8]

Variants

Explorer

Airstrato prototype 002 on pneumatic launcher

It is the most expensive of the two models and with the highest flight performance. It is also the only one able to fly into the stratosphere. It also comes with included components such as transponder and satellite internet connection device that are optional for the Pioneer. It has a larger wingspan, more solar cells and longer endurance. The selling price is $140,000.

Pioneer

It has lower overall performance than the Explorer but has greater maneouverability and rate of climb. It uses the same ground station and the same connection protocol as the Explorer. It can be equipped with all the accessories of the Explorer, including transponder, satellite connection, 4K resolution gimbal camera, FLIR camera, deployable containers etc.

Specifications

AirStrato Explorer

AirStrato prototype 002 in flight

Data from ARCA[9]

General characteristics

Performance

AirStrato Pioneer

AirStrato prototypes 002 and 003 inside hangar

Data from ARCA[10]

General characteristics

Performance

References

  1. ↑ Romanians are testing an unmanned aerial vehicle with amaizing performances, Jurnalul National.
  2. ↑ ARCA is developing a high performance UAV, Romania TV.
  3. ↑ Air Strato first take-off and landing, spacewar.
  4. ↑ AirStrato drones give military performance at "affordable" prices, gizmag.
  5. ↑ Romanian $140,000 drone: stratospheric flying, 20 hours autonomy, Adevarul.
  6. ↑ AirStrato, revolutionary stratospheric drone, Ziua News.
  7. ↑ AirStrato, Affordable, solar powered, stratospheric drone, suasnews.
  8. ↑ http://www.airstrato.com/en/accelerator.html
  9. ↑ http://www.airstrato.com/en/explorer.html
  10. ↑ http://www.airstrato.com/en/pioneer.html

External links

This article is issued from Wikipedia - version of the 8/13/2016. The text is available under the Creative Commons Attribution/Share Alike but additional terms may apply for the media files.